• Home
  • Download PDF
  • Order CD-ROM
  • Order in Print
Table 4-1.  Unit Preventive Maintenance Checks and Service(Continued) - TM-55-2210-223-12_93
Table 4-2.  UNIT TROUBLESHOOTING - TM-55-2210-223-12_95

TM-55-2210-223-12 Oil-Water Separtor 5 GPM Type Seprator 5 GPM Type A 3 Stage NSN 2090-010-076-5849 Manual
Page Navigation
  80    81    82    83    84  85  86    87    88    89    90  
TM 55-2210-223-12 TO 45A2-2-14-41 Section IV.  UNIT TROUBLESHOOTING 4-7 GENERAL. This section contains testing and troubleshooting information for locating and correcting most of the operating troubles which may develop in the locomotive.  Each malfunction for an individual component, unit, or system is followed by a list of tests or inspections which will help you determine corrective action to take.  You should perform the test/inspections and corrective actions in the order listed. 4-8 TROUBLESHOOTING PROCEDURES. The  symptom  index  lists  the  common  malfunctions  which  you  may  find  during  the  operation  or  maintenance  of  the locomotive or its components.  Use the symptom index for quick access to the troubleshooting procedures in table 4-2. This manual cannot list all possible malfunctions that may occur, nor all tests or inspections and corrective actions.  If a malfunction  is  not  listed  (except  where  malfunction  and  cause  are  obvious)  or  is  not  corrected  by  listed  corrective actions, notify intermediate direct support maintenance. SYMPTOM INDEX Troubleshooting Procedure Symptom Page AUXILIARY ELECTRICAL SYSTEM Failure of battery charging circuit  .......................................................................................................................4-11 COOLING SYSTEM Engine overheating .............................................................................................................................................4-12 ELECTRICAL INSTRUMENTS AND CONTROLS Faulty operation of electrical contactors  .............................................................................................................4-13 Faulty operation of interlocks or control fingers  ..................................................................................................4-13 ENGINE Engine cranks but fails to start   ...........................................................................................................................4-14 Engine does not crank ........................................................................................................................................4-15 Engine skips or misses .......................................................................................................................................4-16 Engine stops while in operation  ..........................................................................................................................4-16 LUBRICATING SYSTEM Low lube oil pressure ..........................................................................................................................................4-17 MAIN GENERATOR Main generator flashover ....................................................................................................................................4-17 SANDING SYSTEM Sanding system does not work  ...........................................................................................................................4-17 LIGHTS Headlights do not operate with headlight switch in the ON position .....................................................................4-18 Cab, engine compartment, and step lights do not operate with switch in the ON position   ..............................................................................................................................................4-18 4-10







Western Governors University

Privacy Statement
Press Release
Contact

© Copyright Integrated Publishing, Inc.. All Rights Reserved. Design by Strategico.